Bloomfield 1012 Spécifications

10 Sunnen DriveSt. Louis, MO 63143telephone: 314-678-6336fax: 314-781-2714www.wellsbloomfield.comBLOOMFIELD INDUSTRIESp/n 2m-75844 Rev.H

8OPERATION (continued)ELECTRONIC FEATURESEnergizing the BrewerWhen electric power is applied to the unit, all the lights will ash four times and four

OPERATION (continued)Quality Timer is normally set for 30 minutes. It can be set for 20 minutes by moving a jumper on the controller. See page 17.Af

10BREWING COFFEECAUTION: BURN HAZARDExposed surfaces of the brewer, brew chamber and decanter may be HOT to the touch, and can cause serious burn

CLEANING INSTRUCTIONSPROCEDURE: Clean Coffee BrewerPRECAUTIONS: Disconnect brewer from electric power. Allow brewer to cool.FREQUENCY: DailyTO

TROUBLESHOOTING SUGGESTIONS12SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDYWater won’t heat (NOTE: Models 1016 & 1074 must have power switch ON)Brewer

CAUTION: SHOCK HAZARDLive electrical circuits may be exposed while performing these procedures. These procedures are to be performed by quali

SERVICING INSTRUCTIONSCAUTION: SHOCK HAZARDOpening access panels or removing warmer plates on this brew may expose uninsulated electrical compone

SERVICING INSTRUCTIONS (continued)TEMPERATURE ADJUSTMENTUnplug power cord or turn circuit breaker OFF. Remove top panel. Remove button plug from fro

SERVICING INSTRUCTIONS (continued)IMPORTANT: Water pressure must be between 20 p.s.i and 90 p.s.i. owing pressure. If water pressure exceeds this v

SERVICING INSTRUCTIONS (continued)17REPLACE SOLENOIDUnplug power cord. Turn OFF and disconnect water supply from brewer inlet tting.Remove front pan

NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the f

REPLACE HOT WATER FAUCET COIL(Symptom: Brewer drips continuously from brew head, except when faucet valve is turned OFF.)Remove tank lid assembly per

SERVICING INSTRUCTIONS (continued)19Fig. 20 Keypad Ribbon Cable Hook-UpSET CONTROLLER JUMPERSPlacing the jumper across Q1 sets

CAUTION:CHEMICAL BURN HAZARDDeliming chemicals are caustic. Wear appropriate protective gloves and goggles during this procedure. Never siphon delim

641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers Manual

EXPLODED VIEW & PARTS LISTCABINET COMPONENTS - IN-LINE BREWERS22641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 O

EXPLODED VIEW & PARTS LIST (continued)23641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers ManualCabinet Comp

EXPLODED VIEW & PARTS LIST (continued)CABINET COMPONENTS - LO-PROFILE BREWERS24641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1

EXPLODED VIEW & PARTS LIST (continued)25641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers ManualCabinet Comp

EXPLODED VIEW & PARTS LIST (continued)HOT WATER TANK ASSEMBLY26641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Ow

ELECTRICAL COMPONENTSEXPLODED VIEW & PARTS LIST (continued)27641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owme

TABLE OF CONTENTSSPECIFICATIONSThank You for purchasing this Wells Bloomeld appliance.Proper installation, professional operation and consistentmaint

EXPLODED VIEW & PARTS LIST (continued)INTERNAL PLUMBING COMPONENTS28641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 10

WIRING DIAGRAM 29641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers Manual

WIRING DIAGRAM30641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers Manualp/n 75373

WIRING DIAGRAM (continued)31641 p/n 2M-75844 1012 1040 1072 Owmers Manual641 p/n 2M-75844 1012 1040 1072 Owmers Manualp/n 2M-75361 HEATINGELEMENT1

NOTES

NOTES

10 Sunnen Drive, St. Louis, MO 63143telephone: 314-678-6336 fax: 314-781-2714www.wellsbloomfield.com

FEATURES AND OPERATING CONTROLSFig. 1 Features & Operating ControlsFEATURES AND OPERATING CONTROLS Fig. 1 Features & Operating Controls 2641

PRECAUTIONS AND GENERAL INFORMATIONWARNING: ELECTRIC SHOCK HAZARDAll servicing requiring access to non-insulated components must be performed by qual

INSTALLATION INSTRUCTIONSREAD THIS CAREFULLY BEFORE STARTING THE INSTALLATIONUnpack the unit. Inspect all components for completeness and condition.

INSTALLATION INSTRUCTIONS (continued)NOTE: This equipment must be installed to comply with all applicable federal, state and local plumbing codes an

OPERATIONFig. 4 Brewer Operation DiagramSTART-UP For initial start-up, or if the brewer has not been used for an extended period of time:

OPERATION (continued)7WATER HEATERWater temperature is sensed by an electronic water temperature probe inserted into the water tank. This temperature